differance in water tube and fire tube boilers

The Differences Between Water Tube Boilers and Fire Tube

The water tube boiler can also handle higher pressure in applications that require more than 350 psi, unlike the fire tube boiler, which has greater pressure limitations. The physical size of a water tube boiler unit can often be a deciding factor when choosing between a water tube or fire tube boiler, because these types of commercial boilers

Learn More

Composite Boilers

Recovery of some of this heat loss to the extent of 30 to 50 percent is possible by means of an exhaust gas boiler or water heater. The amount of heat recovered from the exhaust gases depends upon various factors, some of which are, Steam pressure, temperature, evaporation rate required, exhaust gas inlet temperature, mass flow of exhaust gas

Learn More

Fire Tube Boiler - Types, Construction, Working & Applications

Thus, in this article, we have learned what is a fire tube boiler, different mountings, and accessories used for its operation, different types of fire tube boilers, advantages, and disadvantages. Here is a question for the readers, Explain the contrast between a fire tube boiler and a water tube boiler.

Learn More

Comparison between Fire tube and Water tube boilers

Comparison between Fire tube and Water tube boilers A boiler is a device used to generate s team at a desired pressure and tem pe rature by transferring heat energy produced by burning fu el to water to change it to steam.

Learn More

Scotch Marine (Fire Tube ) Boilers | Hurst Boiler

Our two-pass, three-pass or four-pass Scotch Marine(Fire Tube) boilers are available in dryback, wetback, steam or hot water versions; from 15 to 800 hp with pressures to 300 psig. Hurst Scotch Marine boilers are rated to 81% minimum efficiency.

Learn More

Difference Between Fire Tube Boiler and Water Tube Boiler

The difference between fire tube boiler and water tube boiler can be done on various points. These points includes types of fluid flows within the tubes, steam generation rate, floor area required for the steam generation, transportation, efficiency, fluctuating loads, operating cost etc. the knowledge of the difference about these two boiler is very crucial.

Learn More

Firetube vs Watertube Boilers: a Comparison

The firetube boiler passes combustion gas inside a series of tubes surrounded by water in a vessel to produce steam, while a watertube instead sends water through a series of tubes surrounded by combustion gas used to transfer heat energy and produce steam. Here are a few key differences between the two:

Learn More

Boiler Types - Southern Steam Trains

There is an optimum sizing and arrangement for the water tubes, which depends on the boiler's dimensions. Typically, the tubes should be greater than 5 mm in diameter and should be space so as to allow plenty of room for a flame path between them. Increasing the number of tubes may not increase the boiler's ability to generate steam.

Learn More

PDF Which Boiler Type is Right?

In a firetube boiler, water surrounds the furnace and tubes that house the flame and hot gases. Firetube boilers normally range in size from 15 to 2,200 horsepower as a package with design pressures between 15 and 250 pounds for steam and between 30 and 160 pounds for hot water. Firetube boilers are used in both process and heating applications

Learn More

Wetback and Dryback Boilers Compared | Lathrop Trotter

There are two primary Firetube boiler designs: "wetback" and "dryback". The basic difference between a wetback boiler and a dryback boiler is in the rear wall design. The wetback boiler has a rear wall that is surrounded by water, while the rear wall of a dryback boiler is lined with refractory.

Learn More

Water Tube Boiler Vs. Fire Tube Boiler - Student

Water Tube Boiler Vs. Fire Tube Boiler - posted in Student: Hi, I am designing a waste heat boiler and at the moment must decide between Water Tube Boiler or a Fire Tube boiler, My Gas Pressure is about 275 psig My gas flow 167,000 lb/h And my Stream Pressure about 490 psig Initially I thought based on my pressures i should be designing a fire tube boiler but now because of my gas flow i am

Learn More

Fire tube boiler vs water tube boiler-Comparison of boiler

Fire tube boiler vs water tube boiler. Today's lessons will be discussed about difference between fire tube boiler and water tube boiler that means Fire tube boiler vs water tube boiler. Usually two types of boiler is most commonly used in many industries and power generation.

Learn More

Wetback vs Dryback firetube boiler design

Understanding the operational design differences. Firetube boilers are available in either dryback or wetback design. They are identified by the type of reversal (turnaround) chamber, or posterior portion of the combustion chamber, through which flue gasses travel through the furnace to second-pass tubes to heat water within the boiler.

Learn More

what are difference between Water tube boiler & Fire tube

One thought on " what are difference between Water tube boiler & Fire tube boiler? Competitive Exam Questions for Mechanical Engineers - Mechanical Engineering says: February 8, 2016 at 10:34 PM

Learn More

difference between water tube and fire tube boiler - YouTube

water tube gas oil fired boiler, D type water tube boiler, double-drum gas oil boiler for sale - Duration: 1:39. zg boilers 3,675 views

Learn More

Marine boiler -various types- how they work & advantages

Marine boilers are of two types namely the water tube boiler and the fire tube boiler. The water tube type boiler is used for high-pressure, high-temperature, high-capacity applications. The Main boiler design depends on its application, ie. for motor ships, a small fire tube boiler would be satisfactory.

Learn More

Fin Tube Boilers - Energy Solutions Center

Fin tube boilers represent one of a number of pressurized equipment options used to heat water or convert water into steam under controlled conditions. As in a water tube boiler, water passes through boiler tubes while combustion gases remain in the shell side, passing over the tube surfaces.

Learn More

Scotch Marine Firetube Boilers | Superior Boiler

The Scotch Marine Boiler is a firetube boiler, in that hot flue gases pass through tubes set within a tank of water. The general layout is that of a squat horizontal cylinder. One or more large cylindrical furnaces are in the lower part of the boiler shell. Above this is a large number of small-diameter fire-tubes.

Learn More

Problems in Boilers - Marine Study

This white hot fire spread throughout the boiler melting and burning most of the tubes, and also initiated soot fire in the air heater. Water wall and screen tube headers were subsequently found to be blocked solid with plugs of steel which had formed when the molten boiler tubes and run back into their holes.

Learn More

Difference between coiled tube and water tube boiler

The basic difference is that the coiled tube boiler heats the fluid in a serial manner, and the water tube boiler heats in a parallel manner. Because of the difference the water tube boiler is more economical of space and can be used where large volumes of fluid are to be heated.

Learn More

K2 Firetube | U.S. Boiler Company

The NEW K2 Firetube condensing boiler is an addition to the K2 high-efficiency series. Joining the K2 Watertube boiler, the K2 Firetube features a stainless steel vertical firetube heat exchanger and is available in six sizes. All models can be wall-hung and feature 5:1 modulation. The boiler's dimpled, firetube heat exchanger provides lower pressure drop when compared to water-tube heat

Learn More

Steam Generator vs. Steam Boiler | Powerhouse

The water flows through the smaller diameter boiler tubes while the combustion gases travel around them to transfer heat to the water. The boiler tubes in the watertube design carry the heated water inside the tubes between the lower drum (mud drum) and upper drums (steam drum), with the generated steam accumulating in the upper drum.

Learn More

NFB Series | Series | Navien

Totally reinventing fire tube technology from the ground up. Patented stainless steel heat exchanger —eliminates high stress point welds. Advanced user interface and controls with intuitive text display, simplifies boiler setup. Built-in hardware to connect a boiler system pump, 3 zone pumps or 3 zone valves.

Learn More

Boiler Basics: What Are The Different Types Of Boilers

Conversely, in a water tube boiler the water is inside the tubes and the heat source is on the outside. This ability for rapid heat transfer makes water-tube setups ideal for applications with variable load requirements and high pressure demands. Water tube boilers are available in significantly larger capacities than fire-tube style models.

Learn More

Flame impingement of boiler tubes and how to prevent it

Flame impingement of boiler tubes and how to prevent it Flame impingement of steam raising boiler components can cause a number of severe issues that are detrimental to the integrity of the asset. When burner flames make direct contact with the furnace side water walls (or shell plate of the furnace in water tube boilers), the result is

Learn More

What is a Fire Tube Boiler? - ohheating.com

Water-tube boilers are safer by design and generally can operate many years longer than fire-tube boilers. Fire-tube boilers typically have a lower operating costs comparable to similarly sized water tube boilers. A fire-tube boiler is a type of boiler in which hot gases from a fire pass through one or more tubes running through a sealed

Learn More

PDF Watertube Boilers - rananaseemshahid

BENT TUBE BOILERS Watertube boilers of the bent tube design are capable of greater steam capacities, higher pressures, and greater versatility in arrangements such as floor space, head room, and more efficient use of the furnace. The furnace may be lined with watertubes (called a water-cooled furnace) to absorb more radiant heat from the fire.

Learn More

Condensing vs. Non-Condensing Boilers: What's the Difference?

Fire tube: where the combustion gases and furnace flame are inside tubes located in a cylindrical vessel that holds the water and steam. Electrical: where electricity is the main energy source to heat the water, eliminating the need for combustion components inside the boiler or flue stacks to vent harmful exhaust.

Learn More

Differences Between Fire Tube Boiler And Water Tube Boiler

Introduction. WNS series horizontal internal combustion boiler is classic 3-pass wetback oil/gas fired boiler. After fuel is atomized by burner, flame is full of the wave furnace and transfer heat via furnace wall, called 1st pass; the high temperature flue gasses are collected in reversal chamber and then enter 2nd pass, which is grooved tube bundle area through heat convection, air

Learn More

PDF CHAPTER TWO: Boiler Operation Maintenance & Safety Study Guide

Fig. (2) Shape of fire-tube 2.1.3 Water-tube boilers: • Water-tube boilers have water running through the tubes and fire or gases of combustion surrounding the tubes. The water tubes are connected into a steam drum at the top and a mud drum at the bottom. The fire is in the Combustion chamber. The boiler design can also be

Learn More

What is water tube boilers? - ZG steam boiler

Water tube boiler is name from boiler structures such kind of boiler where the water is heated inside tubes and the hot gasses surround them. This is the basic definition of water tube boiler. Actually this boiler is just opposite of fire tube boiler where hot gasses are passed through tubes which are surrounded by water. View more about water tube boiler and fire tube boiler difference.

Learn More

Difference between Fire Tube Boiler and Water Tube Boiler

The main difference between fire tube and water tube is that in fire tube boiler the flue gases flow in the tubes and water flows from the shell and in water tube boiler, water flows from the tubes and the flue gases from the shell or passes over the tubes. This is the key difference between these boilers.

Learn More

Package Boilers - Babcock & Wilcox

Backed by more than 5,000 units and 150 years of experience, B&W's water-tube package and industrial boilers have an established reputation for reliability and proven performance. They are engineered to meet unique capacity, space, fuel, emissions, transportation, installation and other requirements. They offer reliable power with low emissions

Learn More

Boiler Tubes | Inspectioneering

Boiler Tubes are metal tubes located inside of boilers that heat water in order to produce steam. There are two major types of tube boilers: water-tube boilers and fire-tube boilers. In water-tube boilers, water circulates inside the tubes and is heated externally by hot gases generated by the furnace.

Learn More

Chapter 9 - Introduction to Process Technology Equipment

The main components of a water tube boiler are the furnace, the tubes, the drums, the gas/oil burner, and the economizer. Cool water comes in through the inlet and then flows down the downcomer to then be heat in the pipes.

Learn More

Water-tube or fire-tube condensing boiler, which is the

The water-tube boiler may just result in a tube leak, which can be easily contained. Conclusion. Water-tube and fire-tube boilers are complete opposites in terms of the location of the water relative to the hot gases resulting in water-tubes boilers being inherently more efficient in terms of the heat transfer.

Learn More

Boilers and Type of Boilers - Forbes Marshall

Shell and tube boilers are also referred to as fire tube or smoke tube boilers. Fire tube boilers; contain long steel tubes through which the hot gasses from a furnace pass and around which the water to be converted to steam circulates. Fire tube boilers, typically have a lower initial cost, are more fuel efficient and easier to operate.

Learn More

fire tube water tube steam boiler difference

Fire Tube Boiler - Definition, Construction, Working . Difference between Fire Tube Boiler and Water Tube Boiler. The comparison between two boilers namely water tube as well as fire tube mainly includes working pressure, material type, the rate of steam production, the requirement of floor area, efficiency, load handling variation, design, operator skills, the cost for maintenance are

Learn More

fire and water tube boilers - central-harburg.de

PROJECT DETAIL. Product:fire and water tube boilers Standard: ASME, ISO,IBR Packaging Detail: Regular packing or nude packing, or upon customers requirement. Transportation: by land or by sea, depended on the exporting area; Email: [email protected] Inquiry Now

Learn More

A comparison between water tube and fire tube boilers

Fire tube boilers are a lower cost alternative to water tube boilers and are often used for smaller industrial facilities with lower operating pressures. The main advantages of a fire tube boiler are its simple construction, compact size and the ability to easily meet rapid fluctuations in steam demand.

Learn More

Leave your email

We will contact you in the first time and choose the right boiler model for you and provide a reasonable solution.